Search | W108 W109 | On Demand Video

Displaying 1 - 50 of 96
On Demand Video
Cleaning and Detailing a Mercedes Engine Compartment- On Demand Video Instruction
$4.99

Extreme Detailing Part 4: Cleaning and Detailing an Engine Compartment Safely - On Demand Video

Kent will show you how to get it super clean with minimal water and overspray

In this 14-minute video instruction, you will get to see how Kent cleans and details an engine compartment in a W210 E430 using his favorite chemicals and techniques. This includes using less than a gallon of water and controlling the spray rinse so you protect sensitive electrical components.

On Demand Video
$19.99

Door Hinge and Latch Lubrication Procedures - On Demand Video

With the right grease gun and lubricants you can make your doors close oh so smoothly!

Door hinge lubrication has to be one of the most neglected maintenance items on the older models. I think part of the problem stems from the fact owners don't know how to do it or don't know how to acquire the proper grease gun to lubricate those special fittings on the door hinges.

On Demand Video
$15.99

How to Remove Fine Scratches from Your Car's Windshield - On Demand Video

Video instructions using Kent's glass polish kit to remove scratches with less mess and less heat!

This video will take you step by step through the process of using our glass polish kit with a multitool to remove those fine scratches from your windshield or rear hatch glass. It also works great for polishing the water and acid rain out of any glass, including shower doors!

On Demand Video
$2.00

How to Clean Out Plugged Sunroof Drains on 1965 to 1995 Models

Part of Kent's $2 tip video collection. The tip will only cost $2 but you could save considerable money and grief by watching this video.

In this short 2:32 minute video Kent will show you how he first tests the sunroof drains for blockage and then how he goes about cleaning out any blockage.

On Demand Video
Mercedes Muffler Repair - On Demand Video
$12.99

Center and Rear Muffler and Exhaust Pipe Replacement and/or Repair - On Demand Video

Common Rear Exhaust leak troubleshooting, component replacement and hole patching DIY techniques

How can you tell if you have a hole or leak in your exhaust system? What are the symptoms? Can the leak be patched? When will you have to get either a new center muffler or rear muffler or pipes or all three? Can you replace the mufflers yourself and what are the tricks?

On Demand Video
Dragging Brake Dust - On Demand Video
$9.99

Testing for and Troubleshooting Causes of Dragging / Sticking Brakes - On Demand Video

Could be multiple causes - don't assume it is a bad caliper!

Old cars and brake issues go hand in hand. Especially if the car is not driving very often. Brake problems usually first show up as “dragging” or sticking brakes. If this issue is not dealt with immediately it can lead to serious problem including the car catching on fire. 

 

On Demand Video
Mercedes Short Fuel Pump Instructions - On Demand Video
$19.99

1963 to 1973 Short MFI Electrical Fuel Pump Lower Section Resealing Instructions - On Demand Video

Be sure your Mercedes has the "short" style fuel pump. Not all models in those years had one (see description)

MFI (mechanical fuel injection) fuel pumps are notorious for leaking fuel. Leaks are almost always due to age hardened and deformed o-rings inside the pump. Taking the pump off the car, taking it apart, cleaning it and installing new seals will almost always solve the fuel leak problems.

On Demand Video
$18.99

MFI Fuel Injector Tester: Assembly, Testing and Cleaning Operations - On demand Video

A video instruction manual explaining in detail how our special tester kit works

Would you like to find out how well your old (1959 to 1972) mechancial gasoline fuel injectors are working? Now you can do it yourself at home with our custom bench mount hand pump pressure tester and cleaning kit. These are the full instructions that come FREE with the kit.

On Demand Video
Under Body and Under Trim Spot Rust Repair - On Demand Video
$12.99

Under Body and Under Trim Spot Rust Repair - On Demand Video

High moisture "hidden" rust areas have to be treated and coated properly or they will not be permanent

On older Mercedes spot rust can be a hidden problem under side moulding trim, under fenders and rocker panels and inside the bottom edges of doors.

On Demand Video
Mercedes Brake Caliper Removal - On Demand Video
$6.99

Brake Caliper Rebuilding Part 1: How to Remove Frozen Pistons From Brake Calipers - On Demand Video

Part 1 of 3 Parts: For Mercedes brake calipers from the early 1960's to the late 1990's

You can save a lot of money if you can rebuild your old brake calipers, especially on some older models. If you can just get the pistons out of the housings, most calipers are rebuildable, unless they have been subject to road salt or have sat exposed to the weather for years without use.

On Demand Video
Mercedes Front Rotor Removal - On Demand Video
$3.99

Removing the Front Brake Rotor from the Bearing Hub - On Demand Video

Kent will show you some tips on how to remove and replace that front rotor on the older model front hubs

Installing new front rotors on older model Mercedes requires that you remove the rotor from the bearing hub and bolt the new rotor back on. Sounds easy right? Sometimes not! The bolts are on very tight and often take a lot of torque to remove. How do you hold the break rotor while doing this?

On Demand Video
280SEL Transmission Service - On Demand Video
$12.99

Older Automatic Transmission Fluid and Filter Service - On Demand Video

Directly covers most 1960’s Automatics - Indirectly covers 1970’s and Early 1980’s Automatics Directly covers most 1960’s Automatics - Indirectly covers 1970’s and Early 1980’s Automatics

Transmission service on these older Mercedes is very often neglected and it is something you can do yourself. It should be done every 30,000 miles or every 5 years (whichever comes first). After you watch this video you will find out why you should do it yourself!

On Demand Video
Using Lipo Batteries - On Demand Video
$3.99

How to Use Small Lithium Polymer Batteries to Work on Your Car - On Demand Video

If you are into RC (radio control) you will already have these batteries and special charger

Tired of lugging around heavy batteries or battery boosters to test electrical components in your car? It does not have to be a Mercedes. It does not even have to be a car. Anything that runs off 12 volt DC power can be tested by these small, light weight but very powerful batteries.

On Demand Video
$14.99

Manually Operated Sunroof Removal and Service - On Demand Video Manual

Applies directly to all W123 wagons and some 123 sedans and indirectly to other early 111, 108, 114, 115 and 116 models

Manual sunroofs can have problems too. Just like their electrically operated counterparts, most often they will fail due to lack of lubrication. The number one failure point is a broken T handle. Number two is failure of the roof to close properly due to damaged felt feet and plastic slides.

On Demand Video
Early Mercedes Wiper Arm Removal, Replacement and Adjustment Procedure
$2.99

How to Fix Some Early Turn Signal Levesr That Won't Hold Position - On Demand Video

Most 1965 to 1976 models if they still function but lever will not hold. In most cases you can repair it yourself and save big $$$.

An annoying problem on many older Mercedes up to 1980 that have an aluminum housing surrounding the turn signal arm latching assembly. When these wear out the lever will not hold position when you push it up or down.

On Demand Video
$4.99

Waking Up An Old Benz That Has Sat For Years Part 1 - On Demand Video

Kent covers what you may have to do first with the engine and fuel system

When an old Mercedes ( or any other car for that matter ) has sat idle for over a year it can be a challenge to get it safely back on the road again. If it has sat idle for more than 5 years you may find it difficult to even get the engine running. 

On Demand Video
Removing and Replacing an Inside Rear View Mirror
$2.00

Removing and Replacing an Inside Rear View Mirror the Easy Way

Part of Kent's $2 tip video collection. The tip will only cost $2 but you could save considerable money and grief by watching this video. Hard enough to remove and almost impossible to reinstall by hand unless...

Understanding how an inside rear view mirror is mounted is essential for proper removal and replacement. The mirror can be easily damaged if you do not know the tricks to getting it snapped back into the mounting bracket in the head liner.

On Demand Video
Mercedes Check Strap
$6.99

Mercedes Door Check Strap Diagnosis and Replacement - On Demand Video

Common repair that you can do yourself with minimal tools and mechanical experience

Groaning, snaping and jammed door check straps are a common problem on the older models (up through 1995). This is primarily due to age and lack of lubrication. Newer models will soon start having similar problems. Rain water getting inside the doors is the big killer.

On Demand Video
$4.99

Waking Up an Old Benz That Has Sat for Years Part 2 - On Demand Video

After getting the engine running what's next?

When an old Mercedes ( or any other car for that matter ) has sat idle for over a year it can be a challenge to get it safely back on the road again. If it has sat idle for more than 5 years you may find it difficult to even get the engine running.

On Demand Video
Buying a Mercedes Benz
$3.99

Going on the Hunt to Buy an Older Mercedes Benz with Kent Bergsma: Part 1 - On Demand Video

Avoiding three common pitfalls that can become big money pitts

In this 10 minute video class Kent shows you what you should initially look for when checking out an older Mercedes for sale. He routinely does a quick 3 to 5 minute walk around to determine if the car passes his priority three part test. 

Those three areas on inspection are:

On Demand Video
Detailing the Interior of an Older Mercedes Benz by Kent Bergsma
$10.99

Extreme Detailing Part 1: Interior Carpets, Upholstery, and Panels - On Demand Video

Learn how to use some unique products make the job easier, faster and more enjoyable

In this video Kent shares his secrets on how to make the inside of an old Benz look like new again. Now granted, you must have a reasonably good car to start with.  He is not going to show you how to reupholster, change seats and door panels, etc.

On Demand Video
$8.99

How to Clean and Flow Test Your Old Gas or Diesel Injection Pump - On Demand Video

For old 1950 to 1985 Fuel Injected engines that have sat around and not run for years!

In this 9-minute instructional video, Kent explains how to set up his injection pump cleaning and testing kit ( available separately ), and use it to clean out old fuel injection pumps of gum and grime, and then how to test them to make sure they are delivery fuel through every line. 

On Demand Video
$9.99

1965 to 1991 Sedans and Wagons Plastic Door Liner Replacement Instructions - On Demand Video

Covers plastic sheet replacement only. Does NOT cover removing or replacing the door panel itself.

In this 17-minute video instruction, Kent walks you through the steps to install his door liner kit using thick, clear, and high-quality plastic sheets on both front and rear doors. A W123 sedan is shown here, but the principles are similar for other chassis. 

On Demand Video
$9.99

1970 to 1975 D-Jetronic Fuel Pressure Regulators: How They Work / How to Test - On Demand Video

There is a little mystery around these. I will open them up and show you how they work and what they really do.

People call these two units pressure regulators, but really only one of them is. In this xx minute video, Kent will explain how these are different, what each one does, how to adjust them, and how to test them with a hand pump vacuum tester. 

On Demand Video
$8.99

How to Depressurize a D-Jetronic V8 Fuel Injection Rail - On Demand Video

This you MUST do before unhooking any hoses on your 1970 to 1975 D-jet engine or I guarantee you will get sprayed with fuel in your face!

In this 8-minute video, Kent will show you how to quickly depressurize your D-Jetronic fuel system before doing any injector service, replacing any hoses, or hooking up our fuel pressure tester.

On Demand Video
$10.99

Master Cylinder Removal, Bench Bleeding, and Replacement Instructions - On Demand Video

Covers most master cylinders 1968 to 1995. Learn to do it right with minimal loss of fluid and mess.

In this 30 minute instructional video Kent will use a 1972 300SEL 4.5 to show you how to remove the master cylinder with minimal spillage, how to install the tank and bench bleed a new master cylinder, and how to reinstall it with minimal brake fluid spillage while protecting your car's paint. 

On Demand Video
$6.99

1972 to 1980 4.5 450 Engine Thermostat Replacement - On Demand Video

For both D-Jetronic and K-Jetronic engines. You can do this job yourself with these instructions and the special hardware included.

In this 14 minute instructional video Kent will demonstrate how to remove and install a new thermostat in a 450 engine. Here you will see how tight it is to get install in a 300SEL 4.5, but other V8s will have better access.

On Demand Video
$8.99

1972 to 1980 4.5 450 Engine Fan Clutch Replacement Instructions - On Demand Video

For both D-Jetronic and K-Jetronic V8 engines. This will help you get your new fan clutch installed properly with new upgraded hardware.

In this 12 minute instructional video, Kent will demonstrate how to remove and replace the viscous fan clutch in a 1972 300SEL 4.5. Other topics covered will be cleaning and corrosion prevention. This video is included free with the purchase of our fan clutch install kit ( see below).

On Demand Video
$39.99

1970 to 1973 V8 D-Jetronic Points to Electronic Conversion Instructions - On Demand Video

You won't believe the improvement! These are complete step-by-step installation and wiring instructions for your early 3.5 4.5 450 V8 W111, W108, W109, and R107. (NOT for the 6.3)

In this 33-minute instructional video, Kent will show you how to convert your old points ignition to an efficient modern electronic ignition. Rid yourself of those old high-maintenance distributor points forever.

On Demand Video
$29.99

Old 4 and 6 Cyl. Electronic Ignition Installation Instructions - On Demand Video

Complete step-by-step installation and wiring instructions for your old Benz points ignition 1958 to 1972

In this 29-minute instructional video, Kent will show you how to convert your old points ignition to an efficient modern electronic ignition. Rid yourself of those old high-maintenance distributor points forever.

On Demand Video
$16.99

1962 to 1980 Power Sunroof Roof Panel Repair, Lubrication and Installation - On Demand Video

Part 4 of my Early Broken Power Sunroof Series - a multi-part series to repair non-functioning power sunroofs from 1962 to 1980 all models

In this 20-minute instructional video, Kent will walk you through the steps of getting the steel sunroof panel installed properly back into the car's roof. The first step will require cleaning, inspection, and possible replacement of the plastic slides.

On Demand Video
$12.99

1970 to 1975 D-Jetronic V8 Front Engine Short Hose Replacement - On Demand Video

These are the two short coolant hoses in front that hardly ever get changed. What you find when you pull them will surprise you!

In this 23 minute highly detailed video Kent will show you to reasons why and some of the problems you will run into when you change these hoses on your own D-Jet engine. He will take the new parts and show you how to properly install them using the correct hose clamps, sealants and lubes. 

On Demand Video
$10.99

1962 to 1980 Sunroof Drive Cable Service and Repair - On Demand Video

Part 3 of my Early Broken Sunroof Series - a multi-part series to repair non-functioning power sunroofs from 1962 to 1980 all models

In this 13 minute instructional video Kent will show you how to clean your sunroof cable tube, prep your cable for easy installation, lube the cable during installation, show preliminary clutch adjustement, and demonstrate how to get cable to engage the drive assembly using the power switch.

On Demand Video
$12.99

W110 W111 W113 W108 Shock Absorber Replacement - On Demand Video

The ins and outs and tricks to installing new shocks on your old classic. Applies to all models in those chassis ranges.

In this 24-minute detailed step-by-step video instruction, Kent will walk you through the process of how to successfully remove the old shocks and install new ones.

On Demand Video
$16.99

1970 to 1975 D-Jetronic Fuel Injection Repair / Service Instructions - On Demand Video

A commonly neglected service that can lead to poor running and possible engine fire. It is the rubber parts that fail! See video below to believe it!

In this 36-minute instructional video, Kent will walk you through the process of doing a complete fuel hose replacement and fuel injector service on a 1970 to 1975 Mercedes V8 engine with Bosch EFI electronic fuel injection.

On Demand Video
$9.99

1962 to 1980 Power Sunroof Cable Transmission Drive Unit Service and Repair - On Demand Video

Part 2 of my Early Broken Sunroof Series - a multi-part series to repair broken power sunroofs from 1962 to 1980 all models. This covers theory of operation - complete service and repair and installation tips of the drive unit.

The sunroof transmission drive unit moves the cable back and forth to open and close the sunroof. There are 5 gears inside this unit that transfer the incoming drive from the motor ( high speed) to the final drive moving the cable (slow speed).

On Demand Video
$14.99

1962 to 1980 Stuck Non-Tilting Sunroof Removal and Inspection - On Demand Video

Part 1 of Early Broken Sunroof Series - a multi-part series to repair broken power sunroofs from 1962 to 1980 all models

In part one Kent will show you how to get all the sunroof parts off our old Mercedes and on a bench particularly if you sunroof is broken and not moving.  In this 21 minute instructional video here is a list of the subjects he covers:

On Demand Video
$19.99

How to Install New Steering Tie Rod Ball Joint Ends - On Demand Video

Here are the instructions you need to do it right and you can do it yourself!

In this detailed 30-minute video Kent will walk you through the process of installing new tie rod ends on his 1959 Mercedes 220SE. The principles are the same on almost all models from the 1950s up to the 1990s. He will explain the differences in adjustment between the older and newer styles

On Demand Video
$9.99

Repair Leaking Chrome Alloy Wheels with Miracle Paint - On Demand Video

Use multiple coats of Miracle Paint to stabilize and fill the corrosion that causes the tires to leak.

In this video, Kent will show you how he fixed his leaking tires on his chrome alloy wheels by using Miracle Paint. This is a full 22-minute step-by-step instructional video. Watch the video "trailer" below to give you a better understanding of what is involved in this procedure.

On Demand Video
$10.99

1960s Six Cylinder Front Crank Seal and Race Replacement - On Demand Video

On sale so you can see what you would be getting into. For 220S, 220SE, 230, 230SL, 250SL, 250S, 250SE, 280SL, 280S, 280SE and 280SEL (with 6 cylinder engine only)

In this 19 minute instructional video, Kent takes an old 1970 280SE engine in the back of his shop and pulls the harmonic balancer off the front of the engine, removes the old seal, uses his custom-built puller to remove to seal race, and then shows you how to use the tools in his seal replacemen

On Demand Video
$12.99

Front Crank Seal Race Removal and Replacement - On Demand Video

Applies to many gas and Diesel engines from the 1960s through the 1980s

This video will show you how to remove the front crank seal race using the factory tool and using Kent's custom puller. It will also demonstrate a very easy way to install a new replacement race before installing a new seal.

Pages