Bosch D-Jetronic Fuel Injector Testing and Cleaning FULL Kit

Store > Fuel Delivery Products > MercedesSource Kits
This includes the required pressure tank for accurate testing. For 1970 to 1975, D-jet electronic fuel injectors - Ready to clean and test your injectors?

This will give you everything you will need ( except 12-volt power and cleaning fluid ) to bench clean and test your D-jetronic fuel injectors in your own garage or workshop once they are removed from the engine. Complete detailed video instructions are included on how to hook up the tester, perform individual injector tests, internally clean and even back flush each one, and how to interpret your results. Instructions on removing and reinstalling the injectors in your engine are NOT included, but you will find this is a very straightforward job (tips are included in the video below). In most cases, you should plan to replace the fuel hoses, seals, and internal filter screens. These parts are available separately (along with instructions). Please see our list of D-jetronic injector repair parts listed below:

Bosch D-Jetronic Fuel Injector Testing and Cleaning FULL Kit
$129.75
SKU:
GEG-FULLDJETINJTEST
Free Add-Ons Included:

Cleaning and Testing Bosch D-jetronic Fuel Injectors Under Pressure - On Demand Video

Product Details

This is how it works!

It will even flush!

This kit is also available as a "partial" kit if you already own one of our pressure tanks and decide you want to provide your own ( see below):

Tester specifications:

  • 1, 2, and 3-second pulse setting
  • Constant pulse setting
  • Input voltage 12 volts ( via car battery or booster pack )
  • Output voltage 5 volts at 3 amps (universal small injector fitting clips)

Related Products:

$24.00

1970 to 1975 D-Jetronic V8 EFI Fuel Injector Tip and Housing Seals

To prevent intake air leaks, replace your aging tip seals and large body seals. You should always replace with new anytime you remove the injectors.

These are the critical seals that go on the D-jetronic fuel injectors. If they leak air, your engine with idle high, start poorly and run lean, which can damage the pistons. We recommend you replace these whenever you remove and replace the injectors.

$79.95

Bosch D-Jectronic Fuel Injector Testing and Cleaning PARTIAL Kit

For 1970 to 1975, electronic fuel injectors. A pressure tank is required. See notes below. Full kit is available if desired.

With the required pressure tank you will be able to individually test and clean our D-jet fuel injectors. Along with a 12-volt power source, you will need I gallon of cleaning fluid as described in the instructions.

Sale
$78.00

Bosch D-Jetronic Fuel Injector Service Kit

You will need this if you plan to remove and test or replace the EFI fuel injectors in your 1970 to 1975 Mercedes

This is the most complete 1970 to 1975 V8 injector repair kit you can find anywhere.

$32.00

1970 to 1975 D-Jetronic V8 Engine compartment Fuel Hose Replacement Kit

Full kit. Includes enough hose and clamps to replace all 8 rubber supply fuel hoses. DOES not include the 8 short hoses and clamps for the fuel injectors. See related below.

These engine supply fuel hoses are critical to the well-being of your engine. I have seen too many rotten and deteriorating hoses on these D-Jet engines that could easily lead to an engine fire, and they just do not get replaced when they should.

$236.00

1970 to 1973 3.5 4.5 D-Jetronic V8 Points to Electronic Ignition Conversion

The most complete kit available anywhere. You get points conversion, an electronic spark boost module, matched new performance coil and correct ballast resistor, clean install extras, plus 30-minute installation and wiring video instructions.

WARNING - WARNING - WARNING: BEFORE we ship this unit, we MUST have confirmation from you that you have removed the distributor cap, confirmed the size of your rotor ( see below), AND measured the points cam width and height. If your distributor is not exactly the same this kit WILL NOT WORK.