Transmission
What's Wrong Help Needed - Quick Links to the Most Common Problems
If you could just figure out what is wrong you know you could fix it!
W123, USED Diesel Engine
Engine
Diesel Engine Front Crank Bolt Failure and Loss of Pulleys
Pay attention! This is very common and can happen to you if you own a 1968 to 1985 diesel
electric fuel pump added to my 1984 300 CD
1984 300 CD
I added a Mercedes Source electric fuel pump, no other fuel system mods. After inital installation the pump would audibly cycle slowly at idle, and pump speed would aduibly increase with engine speed.
suddenly, the pump now runs at high speed constantly, idle or at highway cruise, no detectable difference. Is this a problem or normal?
Also, any ideas of a material to use to isolate the pump from the chassis to lower the audible pumping sounds?
Chassis Model Number
Forums
1985 300TD Turbodiesel - Boost Intercooler - Any Experience?
My 1985 300TD Turbodiesel runs on SVO. The car has good compression and runs great. The car gets to 60mph in about 13s which I believe is to be what's expected from a well tuned specimen. My aim now is to improve the performance beyond that. I have installed some of the performance-enhancing modifications recommended on this web site, including Monark injectors and a fuel boost pump. (Of course I also have Kent's performance tuning manual which has been very useful;-)
Chassis Model Number
Forums
Seat Bottoms
I will be ordering your kit to repair my sagging drivers seat shortly but want to know if the drivers and passengers seat bottoms are interchangeable. In addition to sagging , the driver's seat has some issues with the MB Tex while my passenger seat is virtually new.
Chassis Model Number
Forums
82 300D Turbo Diesel center dash temp sensor and tube
Easy question. Is there anything that can be done to clean/maintain an existing center dash temp sensor and tube? Thanks for any assistance,
--- Chris Konik
Proud owner, 1982 300D with a fully functional MercedesSource Dual Tank WVO conversion
Chassis Model Number
Forums
$3.95
Pencil Glow Plug Wire End Nuts - Set of 10
All 240D 300D CD TD 190D 300SD 300SDL 350SDL with pencil glow plugs
Engine
Rubber Exhaust Hanger ( Donut ) Replacement
These can be a little tricky to get on
Electrical
Properly Maintaining an Old Car Battery
Neglect is probably the No. 1 Cause of your Benz not starting
79 240d intermittant starting problems
Sometimes when I turn the key nothing happens for asecond or until I wiggle the key a little. Most recently the turn of the did nothing except turn on dash ligts and accesories. After waiting 15 min or so it turned over instantly. Is my tumbler the likely cause or should I be looking elsewhere?