Fuel Delivery
Removing Stubborn Diesel Fuel Injector Heat Shield Washers with Special Tool
Applies to all 200D 220D 240D 300D 300CD 300TD 300SD 190D 300SDL 350SD and 350SDL
W116, New Parts Kits and Manuals
$22.75
60x Diesel Engine Compartment Fuel Hose and Clamp Replacement Kit
For 190D 1984 to 1993 and 300D 300TD 300SDL 350SD 350SDL 1986 to 1993
$14.25
61x Diesel Engine Compartment Fuel Hose and Clamp Replacement Kit
For early diesels 1968 to 1985 220D 240D 300D 300CD 300TD 300SD
$30.75
Late 201 and 124 Chassis Early 140 Chassis Voltage Regulator
For later models with higher amperage alternator
$228.00
617 Diesel Garrett T3 Turbocharger 200K High Performance Overhaul Kit
For 5 cylinder Garrett turbos on 300SD 300D 300CD and 300TD 1978 to 1985. 24 page printed instruction manual included.
$98.50
617 Diesel Garrett T3 Turbocharger Turbine Wheel ( Impeller) and Shaft
For all 5 cylinder Garrett turbos on 300SD 300D 300CD and 300TD 1978 to 1985
$119.00
603 6 cylinder Head gasket Set
1986 to 1987 300D 300TD 300SDL
Fuel Delivery
Stopping Fuel Leaks when Performing a Diesel Compression Test
The fuel from the injection pump can be shut off by following this tip:
1979 300SD Turbo Diesel: after-market turbo advisable?
Ken,
Thanks for the products and advice thus-far.
My 1979 Mercedes 300SD Turbo Diesel is running great (knock on wood!), and always gets a thumbs up.
Question for you and anyone in the forum with experience with my model and after-market turbos.
Would an after-market turbo work with my vehicle?
Yes? No? Why/why not? What to look for/stay away from? Other advice?
Cheers from the Bluegrass State,
Christian
Chassis Model Number
Forums
1978 300SD Oil Leaks
I've been running through a lot of oil lately so I had my engine cleaned thoroughly and ran it at idle for 30 mins. I noticed that oil was leaking from the grate at the bottom of the transmission, but nowhere else immediately noticeable. I suspect that this is the dreaded rear crank leak that requires engine removal, but would appreciate confirmation before I go out and solicit estimates. Am I correct?